VC #10: Partition wall

by | Jul 10, 2023 | Vanconversion | 0 comments

After the interior floor is finished, the right time has come to develop and install our own partition walls to the driver’s cab as well as an additional shelf above the driver’s cab.

Partition walls to the driver’s cabin

For our van we want to leave the driver’s cabin as original as possible so that when stealth camping in cities as little as possible points to the living space in the back of our van. This also means that we want to separate the “living space” in the back from the driver’s cabin. However, a passage from the driver’s cab to the living area should be possible. Precisely because we are planning a passageway, and thus perhaps also bump into the partitions when passing from the front to the rear, we have used particularly stable 21mm thick birch plywood panels here. We can also not fix the partitions very strongly because we have only a few holding points available, so it is ideal if the partitions bring an inherent stability. Here perhaps we need to say that we avoid drilling into the car body to avoid possible rust problems. This means that we only have the substructure prepared by us (see post VC #7: Supporting construction) for fastening.

The direct passage from the driver’s cab into the living area has more than proven itself for us. This way, in bad weather or when we don’t want to allow people to look into the living area, we can comfortably enter and exit via the driver’s cab. This type of access also allows us, despite light in the living area, to take only a few mosquitoes inside when we enter and exit via the driver’s cab in the evening at dusk.

With jigsaw and accurate measurements, the wooden panels are easy to cut. For fastening we take metal angles. The upper edge of the partitions is stiffened by the additional storage above the driver’s cab.

Storage space above the driver’s cab

We have long thought whether we should install an additional shelf above the driver’s cab at all. Unfortunately, our Mercedes Sprinter did not come with a storage tray from the factory. The exact measurement of the shelf has turned out to be difficult and for a long time we had no suitable idea for the attachment.
After a lot of online research, we finally found the solution. We found a manufacturer in the USA who sells four custom-made angles and a template for cutting the shelf to size. We gladly buy these products there, although the price is rather overpriced. The choice is thus reducible to an overpriced possible solution or no storage above the driver’s cab. The shelf wins and it continues to prove its worth. It is only suitable for lighter things, but we often store used clothes and small, light objects above the driver’s cab.

Our vanconversion continues with the completion of the preparations for our electrical installations and the installation of the definitive wall coverings!

Do you like our contribution to the travel community?

If you like our blog and you would like to read and see more of us, we would be very happy if you would like to support us. Often we sit for hours in coffee shops, write our blog, sort out pictures and edit them. That’s quite a large number of coffees together. Maybe you would like to buy us one or two?

0 Comments

Submit a Comment

Your email address will not be published. Required fields are marked *

About us

We are Paddy and Mimi, a travel-hungry couple from tiny Switzerland in the middle of Europe. We call ourselves slow travelers, because we like to spend enough time in one place or country. Therefore we don’t only visit the typical sights but also get to know the culture of the respective country.

Our current location:

Caleta Olivia, Argentina

Our world map

Might interest you too:

Magellanic penguins at Cabo Virgenes

Magellanic penguins at Cabo Virgenes

As we continue our journey, we come across the Magellanic penguins we already know. A short detour of “only” 120 km to go and 120 km to come back takes us to a large Magellanic penguin colony of over 2,000 penguins at Cabo Virgenes. On the Chilean island of Chiloé, we...

Perito Moreno Glacier

Perito Moreno Glacier

As mentioned in the first blog post about Los Glaciares National Park and El Chaltén, we come across the same national park again a few hundred kilometers further south. This time the national park doesn't challenge us in a sporty way, but it still plays on all our...

El Chaltén

El Chaltén

In order to protect the impressive nature of Patagonia, many areas are protected under the regime of national parks. The region in the mountain range between El Chaltén and El Calafate is also united in a large national park: the Parque de Los Glaciares. The...

Our most popular articles

Northern Ruta 40

Northern Ruta 40

After a short time in the north of Chile, we cross over into Argentina. We drive over the Paso de Jama, the Jama Pass, and continue to be impressed by the beautiful, barren landscape. On this pass road we have a few smaller lagoons in front of us, more impressions...

Potosí

Potosí

Bolivia comes up with the next somewhat controversial item on the program. We drive our campervan Ben to Potosí, the historic silver capital of the world. We want to learn about the history of silver in connection with Potosí. Not only can we visit a museum, but we...

Pantanal

Pantanal

Next on our South America trip we visit a beautiful region with an extremely dense wildlife: The Pantanal in Brazil. The name sounds spectacular and exotic to us but translated from Portuguese it just means swamp or swamp region, derived from pântano. It is the...